Induction of protective immune response against both PPRV and FMDV by a novel recombinant PPRV expressing FMDV VP1

Peste des petits ruminants (PPR) and foot-and-mouth disease (FMD) are both highly contagious diseases of small domestic and wild ruminants caused by the PPR virus (PPRV) and the FMD virus (FMDV). In this study, a recombinant PPRV expressing the FMDV VP1 gene (rPPRV/VP1) was generated and FMDV VP1 expression did not impair replication of the recombinant virus in vitro and immunogenicity in inducing neutralizing antibody against PPR in goats. Vaccination with one dose of rPPRV/VP1 induced FMDV neutralizing antibody in goats and protected them from challenge with virulent FMDV. Our results suggest that the recombinant PPRV expressing the FMDV VP1 protein is a potential dual live vectored vaccine against PPRV and FMDV.


Introduction
Foot and mouth disease (FMD) is a severe, highly contagious, clinically acute, economically devastating viral disease of wild and domestic cloven-hoofed animals, such as cattle, pigs, goats, and sheep. It is caused by foot and mouth disease virus (FMDV), a member of the family Picornaviridae, genus Aphthovirus. FMDV contains a 7-8-kb, singlestranded, positive-sense RNA genome that encodes a single polyprotein, which is cleaved into four structural proteins (viral protein (VP)4, VP2, VP3, and VP1) and eight nonstructural proteins (L, 2A, 2B, 2C, 3A, 3B, 3C, and 3D polymerase). The genome is enclosed within a nonglycosylated, icosahedral capsid comprising 60 copies each of VP1-4 [1]. Seven immunologically distinct serotypes (A, O, C, SAT1, SAT2, SAT3, and Asia1) were identified on the basis of a VP1 coding region sequence. VP1 is exposed on the surface of viral particles and is the main antigen to elicit a neutralizing antibody response [2,3]. Currently, FMD is mainly controlled by inactivated virus vaccines, which provide only short-term protection (4-6 months), and may create carrier animals [4,5].
Peste des petits ruminants (PPR) is a highly contagious disease of domestic and wild small ruminants caused by the peste des petits ruminants virus (PPRV) and is responsible for serious socioeconomic problems in some of the poorest developing countries [6][7][8]. PPR was first reported in the Ivory Coast in 1942 and later found in the Middle and Near East, southwest and central Asia [9][10][11][12], and recently in China [13]. PPRV, which is a member of the genus Morbillivirus belonging to the family Paramyxoviridae [14], contains a linear, non-segmented, single-stranded, negative-sense, 15948-bp, RNA genome, which encodes six structural proteins, nucleocapsid (N), phosphoprotein (P), matrix (M), fusion (F), hemagglutinin (H) and polymerase (L), and two nonstructural proteins, C and V that are genomically encoded in the order of 3′-N-P/C/V-M-F-H-L-5′ [15,16]. An attenuated PPRV strain, Nigeria/75/1, derived from serial-passage in Vero cells, has been widely used as a safe and efficacious live vaccine to control PPR infections [17].
Several studies have indicated that recombinant paramyxoviruses are effective and genetically stable vectors with many advantages. It is easy to generate recombinant paramyxovirus vectored vaccine candidates using reverse genetic techniques, the recombinant vaccine could be used to prevent two diseases to reduce the costs, and it could potentially be used as a DIVA (Differentiating Infected from Vaccinated Animals) vaccine [18][19][20]. Rinderpest virus, which is also a member of the genus Morbillivirus, has been used as vector expressing FMDV epitopes [21]. In our previous study [22], reverse genetics for PPRV was successfully established, providing a novel method to develop bivalent, live-vectored vaccines against PPRV and other important viral diseases in goats and sheep, such as FMDV, Rift valley fever, and bluetongue virus. In this study, we constructed a recombinant PPRV expressing FMDV VP1 and its immunogenicity against PPRV and FMDV was evaluated in goats.

Plasmid construction and rescue of recombinant viruses
The plasmid pN75/1 insertion ( Figure 1A) contained a fulllength N75/1 cDNA sequence flanked with a hammerhead ribozyme sequence (HamRz), hepatitis delta virus ribozyme sequence, and insertion sequence (a gene start sequence, Not I and Pme I restriction sites, a gene end sequence, and an intergenic CTT trinucleotide), and helper plasmids (pCA-N, pCA-P and pCA-L) were constructed as previously described [22]. The cDNA for the open reading frame (ORF) of the FMDV VP1 (Asia1) protein was synthesized according to a published sequence (GenBank accession no.: GU931682). The Not I restriction sequence (bold), Kozak sequence (gccgccacc, low case and italic) and the ATG initiation codon were introduced at the 5′ end of the cDNA encoding VP1; the TAA termination codon and Pme I restriction sequence (uppercase and italic) were introduced at the 3′ end of the cDNA encoding VP1, and the final DNA fragment (GCGGCCGCgccgccaccATGactaccaccact……cctg agaaacagTAAGTTTAAAC) was treated with Not I and PmeI and inserted into the plasmid pN75/1 insertion between Not I and PmeI sites. The resulting pN75/1-VP1 plasmid was used to rescue the recombinant virus. The method to rescue the recombinant virus was described previously [22]. Briefly, 90% confluent Vero cells in one well of a 6-well plate were transfected with the plasmids pCA-N (2 μg), pCA-P (1 μg), and pCA-L (1 μg) together with 4 μg of pN75/1-VP1. Lipofectamine 2000 reagent (Invitrogen, Carlsbad, CA, USA) was used for transfection following the manufacturers' instructions. After 7-9 days of incubation at 37°C, the cells and supernatants were collected and freeze-thawed twice and then passaged in fresh cells to propagate the rescued viruses. Supernatants from cytopathic effect-positive wells were used to propagate viral stocks in Vero cells. The complete genomic sequences of the rescued viruses were confirmed by sequencing. The rescued virus was named rPPRV/VP1.

Immunofluorescence assay (IFA)
Vero cells grown in 24-well plates were infected with N75/1 or rPPRV/VP1 at a multiplicity of infection (MOI) of 0.1 and incubated for 3 days. The cells were fixed with Figure 1 Plasmid construction for recombinant PPRV rescue. (A) pN75/1-insertion was constructed previously [22] through insertion of a morbillivirus gene start (GS) sequence, Not I and Pme I sites, gene end (GE) sequence, and CTT intergenic trinucleotides between the P and M genes of genomic PPRV cDNA. (B) The VP1 ORF with a Kozak sequence at the 5' end of the ORF was inserted into plasmid pN75/1-insertion to generate plasmid pN75/1-VP1.

Western blotting
Vero cells were infected with N75/1 or rPPRV/VP1 at an MOI of 0.1 and incubated for 5 days, and BHK-21 cells were infected with FMDV JSL/06 at an MOI of 0.1 and incubated for 12-16 h. The N75/1 and rPPRV/VP1 particles were both purified by sucrose gradient centrifugation with 60%, 40% and 20% density (140 000 g). The cell extracts of Vero and BHK-21 and purified virus particles were analyzed by sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE) and blotted onto a nitrocellulose membrane, which was then incubated with anti-FMDV-VP1 rabbit serum (Asia1 type) [26] or anti-PPRV-N rabbit serum produced through immunization with purified recombinant PPRV N expressed in E.coli as the first antibody, and horseradish peroxidase-conjugated goat anti-rabbit IgG (Sigma-Aldrich) as the secondary antibody. Immunostained proteins were visualized with 3,3′-diaminobenzidine reagent. Mock-infected Vero cells and mock-infected BHK-21 cells were used as controls.

Vaccination and viral neutralizing antibody (NA) assay
One-year-old black goats (a local breed of Yunna Province, China) without neutralizing antibodies to FMDV (titre < 8) and PPRV (titre < 5) were immunized by intramuscular injection at the neck with a 50% tissue culture infective dose (TCID 50 ) of 6 × 10 6 rPPRV/VP1 or N75/1. Sera were collected at 14, 21, 28, and 40 days postvaccination for NA assays. The NA to PPRV N75/1 were titrated in Vero cells as described previously [22,24] and the NA to FMDV JSL/06 was titrated in BHK-21 cells following the protocol recommended by the World Organization for Animal Health (Office International des Epizooties) [23]. Antibody titers were expressed as the reciprocal of the final dilution of serum in the serum/virus mixture which neutralized an estimated 100 TCID 50 of virus at the 50% end-point [27].

Challenge study
Goats vaccinated with N75/1 or rPPRV/VP1 were transferred from a normal sheepfold to a level 3 animal facility, where the animals were acclimated for 1 day before viral challenge. Each goat was challenged with virulent FMDV JSL/06 at 40 days post-vaccination by two intradermal injections to the tongue (0.1 mL at each point; a total of 1000 goat infectious dose 50 of FMDV for each goat). The animals were observed for 14 days post-challenge. Rectal temperature (°C) was measured daily and heparinized blood and oropharyngeal swabs were collected at different days for FMDV detection by inoculation of BHK-21 cells [28]. Simultaneously, lesions and clinical signs were observed and evaluated daily and scored as follows: 0: no water vacuole or ulceration appeared. 1: a water vacuole or ulceration was only found at the injection point. 2: one water vacuole or ulceration was found on the tongue surface, rhinarium, gingiva, or lips, but not at the injection point. 3: two or more water vacuoles or ulcerations were found on the tongue surface, rhinarium, gingiva, or lips, but not at the injection point, or water vacuoles or ulcerations were found at one ungula. 4: two or more water vacuoles or ulcerations were found on the tongue surface, rhinarium, gingiva, or lips, but not at the injection point, while water vacuoles or ulcerations were found at one or more ungulas.

Statistical analysis
Statistical analyses were performed by two-way analysis of variance (ANOVA) or t-tests using GraphPad Prism statistical software (GraphPad Software, Inc., La Jolla, CA, USA). A probability (p) value < 0.05 was considered statistically significant, and < 0.01 statistically very significant.

Generation of recombinant PPRV expressing FMDV VP1
To construct a recombinant PPRV expressing the FMDV VP1 protein (rPPRV/VP1), the FMDV VP1 gene was inserted in the genome cDNA of PPRV N75/1 ( Figure 1A) between the P and M genes ( Figure 1B). VP1 gene insertion in the genome of rescued recombinant virus rPPRV/ VP1 was confirmed by reverse transcriptase polymerase chain reaction (RT-PCR) (data not shown) FMDV VP1 expression in rPPRV/VP1-infected Vero cells was confirmed by IFA. Both rPPRV/VP1-and N75/1-infected Vero cells were positive to anti-N75/1 mouse serum [24,25] by IFA (Figure 2A). rPPRV/VP1-infected Vero cells were positive, while N75/1-infected Vero cells were negative to rabbit serum anti-FMDV(Asia1 type) VP1 (Figure 2A). To determine whether the foreign gene insertion affected the replicative ability of the vector virus, growth curves for rPPRV/VP1-and N75/1-infected Vero cells were determined and compared. The TCID 50 was quantitated using previously described methods [29]. The results show no significant differences in growth titer at different times post-infection between the two viruses ( Figure 3). The genetic stability of the FMDV VP1 gene within rPPRV/VP1 was assessed by serially passaging the virus for 10 times in Vero cells. After 10 passages, the presence of a genomic FMDV VP1 sequence was confirmed by RT-PCR and genome sequencing (data not shown). FMDV VP1 expression in rPPRV/VP1-infected Vero cells was confirmed by IFA and western blotting (data not shown).

rPPRV/VP1 induced FMDV and PPRV NA in goats
To evaluate the immunogenicity of the recombinant virus, sera were collected from six rPPRV/VP1-vaccinated goats and four N75/1-vaccinated goats at 14, 21, 28, and 40 days post-vaccination and subjected to the NA assay for FMDV and PPRV. As shown in Figure 4A, all animals underwent serum conversion to PPRV (NA titer ≥ 10) by 14 days post-vaccination and PPRV NA titers gradually increased until 40 days post-vaccination. The NA titer to PPRV ranged from 500 to 800 and 500 to 1100 at 28 and 40 days post-vaccination, respectively. There was no statistically significant difference in PPRV VN titers between rPPRV/ VP1-vaccinated goats and N75/1-vaccinated goats at different days post-vaccination (p > 0.05). rPPRV/VP1 also induced significant FMDV-specific NA responses. At 14 days post-vaccination, five of six animals vaccinated with rPPRV/VP1 showed FMDV VN titers ≥ 8. Afterward, FMDV NA titers continually increased. At postvaccination days 28 and 40, FMDV NA titers in all six animals were 11-28 and 14-34, respectively. As the control, all four N75/1-vaccinated animals showed postvaccination FMDV NA titers of < 8 ( Figure 4B). There was a statistically significant difference in FMDV VN titers between rPPRV/VP1-and N75/1-vaccinated goats at different days post-vaccination (**, p < 0.01). The temperature of all the animals inoculated with rPPRV/VP1 or N75/1 remained normal after vaccination.

rPPRV/VP1 protects goats from virulent FMDV challenge
To determine whether rPPRV/VP1 vaccination provided protective immunity against FMDV, the above six rPPRV/VP1-vaccinated goats and four N75/1-vaccinated goats were challenged with the virulent FMDV JSL/06. In the rPPRV/VP1-vaccinated group, no animal showed a notable change in body temperature after challenge. In contrast, all animals in the N75/1-vaccinated group developed fever by 2-4 days post-challenge (data not shown). Other than the FMDV inoculation point of one animal, no lesion was found on the oral mucosa or tongue surface in any rPPRV/VP1-infected animals postchallenge. However, vacuoles and/or ulcerated lesions were found in all N75/1-vaccinated animals post-challenge. Other than the FMDV inoculation points, water vacuoles or ulcerations were found on the tongue surface, gingiva, lips, and/or ungula of all control animals at different times 2-9 days post-challenge (data of photos were not shown). The severity of the lesions in each animal was quantitated using a scoring system based on clinical observation as described in the Material and methods section ( Figure 5), which shows significant statistical differences in lesion scores between rPPRV/VP1-and N75/1-vaccinated animals (p < 0.01). Heparinized blood and oropharyngeal swab samples were also collected for FMDV isolation at 2, 4, 7,  18, 20, 22, 25, 26, and 29) were inoculated by intramuscular injection with rPPRV/VP1 and four goats (nos. 361, 28, 32 and 35) were inoculated by intramuscular injection with N75/1. The sera were collected at 14, 21, 28, and 40 days post-inoculation and were tittered for PPRV NA (A) and FMDV NA (B). The data were analyzed by the two-way ANOVA method using the GraphPad Prism statistical software (**, p < 0.01). and 9 days post-challenge. Among six rPPRV/VP1-vaccinated animals, FMDV was recovered from the blood samples of 1-2 animals and from the oropharyngeal swabs of 1-3 animals at different detection times. However, FMDV was recovered from blood samples and oropharyngeal swabs of all four N75/1-vaccinated animals at different detection times ( Figure 6). The results indicate that rPPRV/VP1 provided significant protection against challenge of virulent FMDV in goats.

Discussion
In the present study, we generated the recombinant PPRV vaccine strain N75/1, which expressed the FMDV VP1 protein. This recombinant virus, rPPRV/VP1, induced 20-40 NA titer against FMDV and a comparable PPRV NA titer to that induced by N75/1 in goats. Moreover, rPPRV/VP1 provided significant protective immunity against FMDV challenge in goats. Our results suggest that rPPRV/VP1 is a potential dual, live-vectored vaccine against PPRV and FMDV.
The synthesis of VP1 gene was based on the sequence of FMDV isolate JSL/06 (GenBank accession no.: GU 931682). The FMDV JSL/06 had been adapted in BHK-21 cells and is currently used as a master seed to manufacture inactivated vaccine for the controlling of FMDV Asia 1 in china. We sequenced the vp1 gene of the JSL/ 06 vaccine master seed and the JSL/06 challenge virus stock. There is no amino acid difference of VP1 between the vaccine seed and the challenge stock, and only one amino acid difference between the synthesized VP1 and that of the vaccine seed or the challenge stock.
We employed PPRV N75/1 as a live vaccine vector because it was shown to be highly immunogenic and induced a prolonged high level of PPRV NA in goats and sheep [8,17]. The rPPRV/VP1 induced an NA titer against PPRV that was comparable to that of N75/1 in goats and consistent with that of a previous report [22]. rPPRV/VP1 also showed a similar growth titer to the parent virus in Vero cells, which was different from that in a previous report regarding a recombinant rinderpest virus expressing partial sequences of the FMDV capsid VP1 protein [21]. A previous study had described that recombinant RPV expressing partial sequences of the FMDV capsid VP1 protein could not induce detectable neutralizing antibody against FMDV and provide poor protection against FMDV challenge [21]. For this reason, we vaccinated animals with a higher dosage (6 × 10 6 TCID 50 ) and got improved results in neutralizing antibody response and protection efficacy. Even though this dosage is too high for future field application, our study demonstrates that the strategy of PPRV vectored VP1 vaccine successfully works to induce detectable FMDV neutralizing antibody and provides significant protection against FMDV challenge, because the same antigen in a different animal species or with a different expression vector may result in a significantly different magnitude of immune response. In addition, the form of antigen expression might significantly impact the immune response; cytoplasmically expressed antigens generally have a bias towards presentation through the MHC-I pathway and therefore to induce a CD8+ T cell-mediated response. Secreted or cell membrane displayed antigen may induce more humoral immunity. In future studies, we will try to generate recombinant PPRV expressing the secreted VP1 or entire P1 and hope to get better neutralizing antibody responses with relative lower dosage. We will also try to test if repeat lower dose or combination use with whole virus inactivated vaccine (priming-boost) could improve antibody response and protective efficacy.
Compared to inactivated whole viral vaccine (FMDV NA titer is around 100) [30], rPPRV/VP1 elicited a relatively low level of FMDV NA (titer < 40) in goats, but provided significant protection from challenge of virulent FMDV; however, we can also get better immune effect through two dose vaccination, which could greatly increase the neutralizing antibody titer according to our previous study results [19,24,31]. Although the correlation between FMDV NA titer and protective efficacy in cattle has been well established [32][33][34], previous studies have shown that the protection against FMD is related not only to humoral immunity, but also to cellular immunity [35][36][37]. Previous studies have also shown that swine immunized with recombinant adenovirus expressing FMDV VP1 were completely protected against virulent FMDV challenge, even though the NA (titer < 40) induced by recombinant adenovirus expressing FMDV VP1 was significantly lower than that in swine inoculated with inactivated FMD vaccine [38,39]. Also, other reports showed that swine or cattle immunized with adenovirus expressing the FMDV P1 protein were protected against virulent FMDV challenge at post-vaccination day 7, although an NA titer was undetectable [28,40]. Although rPPRV/VP1 provided significant clinical protection, FMDV was still detected in blood samples or oropharyngeal swabs from partially immunized goats. Similar results were also observed in other studies with inactivated vaccines [4,41]. These results suggest that rPPRV/VP1 has a potential value for future application. In many countries, goats and sheep develop PPR, which results in huge economic losses and also presents a risk factor for FMD. The use of the live PPRV vaccine as a vector to develop recombinant vaccines against FMDV can control these two important diseases. Vaccination of rPPRV/VP1 provides clinical protection and probably decreases the FMDV transmission among goats or sheep.
To rapidly respond against future potential outbreaks, effective and emergent vaccinations should be developed as soon as possible. Currently, widely used inactivated whole viral FMD vaccine usually requires 7-10 days to develop protective immunity and induces only a short protective period [4,5,30]. A priming-boost regime presents an option to generate a rapid immune response and long-lasting protection. However, two doses of vaccination increases vaccination and labor costs. Also, the cost is increased because the inactivated FMD vaccine must be manufactured in a high-level biosafety facility. Using a PPRV vectored vaccine can prime the immune response to FMDV and may induce a long-lasting protection against FMD and PPR without the need for multiple doses of inactivated FMDV vaccine, thereby limiting the costs.
Competing interests ZB, WC, and CY are inventors on a pending patent application for the recombinant virus rPPRV/VP1. The remaining authors declare no financial or non-financial competing interests in the publication of this work.
Authors' contributions CY performed the experimentation, including vaccination, challenge, and neutralizing antibody titer assay. WC performed the plasmid construction, rescue of the recombinant viruses, the immunofluorescence assay, western blotting and challenge, and contributed to the drafting of the manuscript. ZW, QH, XW, JG, and QY contributed to plasmid construction and rescue of the recombinant virus. HZ contributed to the vaccination and challenge experiments. CX provided general supervision. ZB designed the study, provided general supervision, and prepared the manuscript. All authors have read and approved the submission of the manuscript.